Product ID:WASH PRIMER ACTIVATOR, 3860-1
MSDS Date:08/14/1995
FSC:8010
NIIN:00N026230
MSDS Number: CCWDJ

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SOUTH EL MONTE, CA 91733
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

0.0 @ 20C

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 10%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3/3 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

1.0 @ 20C

CAS: 1336-21-6

RTECS: BQ9625000

Fraction By Weight: 10%

OSHA PEL N/K

ACGIH TLV: N/K

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CAN CAUSE IRRITATION AND
REDNESS, TEARING OR BLURRED VISION. SKIN:MODERATE IRRITATION
POSSIBLE FROM PROLONGED EXPOSURE, DEFATTING AND DERMATITIS.
INHALATION:NASAL IRRITATION, HEADACHE, DIZZ INESS, NAUSEA.
INGESTION:GASTROINTESTINAL IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
WEAKNESS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS.

First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION IMMEDIATELY. SKIN:WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. INHAL:REMOVE TO FRESH AIR. IF BRTHG
IS DFCLT , ADMIN OXYG. IF BRTHG HAS STOPPED, GIVE ARTF RESP. GET
MED ATTN. INGEST:DO NOT INDUCE VOMITING, KEEP PERSON WARM & QUIET.
GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:>212F,>100C
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID -CLASS IIIB. CONTAINERS
MAY DEFORM OR EXPLODE WHEN EXPOSED TO EXTREME HEAT. DECOMPOSITION
PRODUCTS MAY YIELD OXIDES OF CARBON AND NITROGEN.

Spill Release Procedures:REFERS TO SECTIONS FIRE & EXPLO RISK, HEALTH
HAZARD DATA, REACTIVITY DATA, SPILL/LEAK PROCEDURES & SAFE HNDLG &
USE INFO SECTIONS. ELIM ALL IGNIT SOURCES, ABSORB LIQ IN ABSORBANT
MATL & PREVENT SPREAD ING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:ALTHOUGH THIS COATING IS A WATERBORNE
OF LOW TOXICITY, FOLLOW PRECAUTIONS OF THIS MSDS TO PREVENT
OVEREXPOSURE.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED, SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUALS (VAPOR,
LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS IN THIS DATA SHEET
MUST BE OBSERVED.

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, NIOSH
APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF ENVIR CONTROL.
OSHA REGS ALSO PERMIT OTHER NIOSH APPRVD RESPS UNDER SPECIFIED
CNDTNS. (SEE SFTY EQUIP SUPPLIER). ENGINEERING (SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECH (GEN AND/OR LOC EXHAUST) VENT TO
MAINTAIN EXPOS BELOW TLV(S) AND/OR USE NIOSH APPRVD (SUPDAT)
Protective Gloves:CHEMICAL & SOLVENT RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . PVNT
RPTD/PRLNGD SKIN CONT W/GB PROT HAND CREAM, WEAR IMPERVIOUS
(SUPDAT)
Work Hygienic Practices:"WASH HANDS BEFORE EATING OR USING REST ROOM,
SMOKE IN SMOKING AREAS ONLY."
Supplemental Safety and Health
RESP PROT:OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE. VENT:AIR SUPPLIED RESPIRATORS. OTHER PROT EQUIP:CLOTHING
& CHEMICAL RESISTANT BOOTS.

Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.01
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:98.80

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:DECOMPOSITION PRODUCTS MAY YIELD
OXIDES OF CARBON AND NITROGEN.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE
REGULATIONS. CONTAMINATED ABSORBANT SHOULD BE INCINERATED OR SENT
TO AN APPROVED LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.